Product ID:GULF GEARLUBE SAE 80 W 90,10502128
MSDS Date:01/25/1989
FSC:9150
NIIN:01-035-5393
MSDS Number: BWLDT

PETRO-CANADA INC

150 6TH AVENUE
CALGARY, AB
CA

Emergency Phone: 416-827-4188

Info Phone: 416-827-4188/644-6012

Cage: 38766

PETRO-CANADA INC

2844 CALGARY, AB CA

Telephone: 403-296-3000

Cage: 38766

BASE OIL

CAS: 68551-18-8

Fraction By Weight: >91%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

EXTREME PRESSURE ADDITIVE

Fraction By Weight: <6%

ADDITIVES

Fraction By Weight: <3%

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
TRACT. ACUTE- MAY CAUSE EYE, SKIN, RESPIRATORY & GI TRACTS
IRRITATION. PROLONGED/REPEATED SKIN CONTACT MAY CAUSE DERMATITIS.
INHALATION OF HEATED MISTS/VAPORS MAY CAUSE RESPIRATORY TRACT
IRRITATION. HARMFUL IF INGESTED. ASPIRATION HAZARD. CHRONIC- MAY
CAUSE SKIN DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE, SKIN, RESPIRATORY AND GASTROINTESTINAL
TRACTS IRRITATION, REDNESS AND PAIN OF EYES; SKIN DERMATITIS;
NAUSEA, VOMITING, HEADACHE AND DIZZINESS
Medical Cond Aggravated by Exposure:DUE TO ITS IRRITATING PROPERTIES,
REPEATED SKIN CONTACT MAY AGGRAVATE AN EXISTING DERMATITIS.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WIPE OFF EXCESS. WASH SKIN WITH
SOAP & WATER. ORAL:DO NOT INDUCE VOMITING. IFCONSCIOUS, DRINK 3
GLASSES OF WATER/MILK. SEEK IMMEDIATE MEDICAL ATTENTION. IF
SPONTANEOUS VOMITING OCCURS, MONITOR FOR BREATHING DIFFICULTIES.

Flash Point Method:COC
Flash Point:410F,210C
Extinguishing Media:WATER FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T USE
DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE REIGNITED.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:TOXIC FUMES, GASES OR VAPORS MAY EVOLVE
ON BURNING. CONTAINER MAY RUPTURE ON HEATING.

Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. STOP LEAK. DIKE
SPILLS. USE PUMP TO TRANSFER LARGE SPILLS TO CONTAINER FOR
DISPOSAL. REMAINING LIQUID/SMALL SPILLS CAN BE TAKEN UP ON SAND,
CLAY, EARTH & SHOVELD INTO CO NTAINERS. PREVENT RUN-OFF TO ENTER
WATERWAYS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL PLACE. KEEP AWAY FROM
FLAME AND INCOMPATIBLE MATERIALS. KEEP CONTAINER CLOSED.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. WASH
THOROUGHLY AFTER HANDLING. AVOID BREATHING MISTS OR VAPORS. KEEP
OUT OF REACH OF CHILDREN.

Respiratory Protection:NON REQUIRED UNDER NORMAL CONDITIONS. IF HIGH
VAPOR OR MIST CONCENTRATIONS EXPECTED, USE NIOSH-APPROVED
RESPIRATOR FOR ORGANIC VAPORS AND MISTS.
Ventilation:ADEQUATE
Protective Gloves:LATEX, RUBBER RECOMMENDED
Eye Protection:SAFETY GOGGLES IF CONTACT POSSIBLE
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN.

HCC:T6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:815F- 1202F
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE STRAW LIQUID - CHARACTERISTIC ODOR
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, SULFURIC ACID, SODIUM HYDROXIDE
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SULFUR DIOXIDE AND OTHER UNIDENTIFIED DECOMPOSITION PRODUCTS.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. CONTROLLED INCINERATION IS RECOMMENDED
UNLESS DIRECTED OTHERWISE BY APPLICABLE ORDINANCES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.